Service Information: Zenair
Alternative Names: (Aircraft Manufacturing & Development)
There will be over 135,000 documents in our Service Information Indexes.
Most SBs are displayed in PDF format. (Use your Browser's 'Edit | Find' function to locate an SB by number.)
Search Within this page
Table of Contents
Flight Manual Supplements • Information Manuals • Installation Instructions • Maintenance Manual Supplements • Maintenance Manuals • Miscellaneous • Notification Letters • Owner's & Flight Manuals • Parts Catalogs • Pilot's Operating Handbooks • Safety Alerts • Safety Notices • Service Bulletins • Service Letters • Service Manuals • Training Manuals • Weight & Balance Information
| Name | Revision | Lang | Subject | Date |
|---|---|---|---|---|
| FMS E508440 | en | Zenair CH2000 Trainer with Lycoming 0-235-N2C | 04/26/2004 |
| Name | Revision | Lang | Subject | Date |
|---|---|---|---|---|
| IM E508435 | en | AMSafe Aviation Inflatable Restraint System - System Description - V23 - Three-Point Seatbelt Airbag Restraint with Dual Sensor EMA | 01/20/2004 |
| Name | Revision | Lang | Subject | Date |
|---|---|---|---|---|
| II 02 | 1 | en | New Nose Gear Set-Up | 03/30/2000 |
| Name | Revision | Lang | Subject | Date |
|---|---|---|---|---|
| MMS E508449 | en | Instructions for Continued Airworthiness - AMSafe Aviation Inflatable Restraint (AAIR) V23 System for Zenair CH2000 Series | 01/12/2004 |
| Name | Revision | Lang | Subject | Date |
|---|---|---|---|---|
| MM | en | Zodiac 601XL/601XLi/650LS/650LSi - Continental 0-200 Engine | 06/30/2009 | |
| MM | 1 | en | Zodiac 601XL/601XLi/650LS/650LSi - Continental 0-200 Engine | 10/31/2009 |
| Name | Revision | Lang | Subject | Date |
|---|---|---|---|---|
| NL 2008 - April | en | Canopy Opening in Flight | 04/15/2008 | |
| NL 2008 - August | en | Control Cable Tension and Inspection of Ailerons and Rear Wing Root | 08/11/2008 | |
| NL 2009 - January | en | Securing Control Surfaces when Aircraft is Parked | 01/07/2009 | |
| NL 2009 - September | en | 41 Page Check List - Inspection (Checklist) | 09/03/2009 | |
| NL 2010 - January | en | So that an AMD SLSA Zodiac 601XL/650 Aircraft Owner/Operator can Apply to his Local FAA FSDO/MIDO for a Special Flight Permit | 01/27/2010 | |
| NL 2016 - December | en | Bungee Pin at Nose Gear. Touching Nose Gear Strut | 11/30/2016 | |
| NL 2020 - January | en | Aircraft Manoeuvres | 01/14/2020 | |
| NL 2020 - January | en | Elevator Stop | 01/20/2020 | |
| NL 2020 - January | en | Engine Mount Cracks - Rotax | 01/06/2020 | |
| NL 2020 - January | 1 | en | Electrical Systems for Aircraft with Engines that must have Continous Power to Operate | 01/07/2020 |
| NL 2020 - January | B | en | Door Upgrade | 01/08/2020 |
| NL ZE-2009-03 | en | Clarification of Speed Limitations and Replacement of Pages 2.1 and 2.2 of CZAW Flight Manual (POH) for CH 601 XL (Ultralight Version) | 07/31/2009 |
| Name | Revision | Lang | Subject | Date |
|---|---|---|---|---|
| OM (Supp 3) |
14 | en | CH2000 Trainer with Lycoming 0-235-N2C | 10/15/2003 |
| OM (Supp 2) |
14 | en | CH2000 Trainer with Lycoming 0-235-N2C | 10/15/2003 |
| OM | 14 | en | CH2000 Trainer with Lycoming 0-235-N2C | 11/04/2002 |
| Name | Revision | Lang | Subject | Date |
|---|---|---|---|---|
| PC | en | CH2000 Trainer | 04/30/2005 |
| Name | Revision | Lang | Subject | Date |
|---|---|---|---|---|
| POH | en | Zodiac 601XL/601XLi/650LS/650LSi - Continental 0-200 100 HP | 07/08/2009 | |
| POH | 1 | en | Zodiac 601XL/601XLi/650LS/650LSi - Continental 0-200 100 HP | 10/31/2009 |
| POH | 2 | en | Zodiac 601XL/601XLi/650LS/650LSi - Continental 0-200 100 HP | 02/28/2010 |
| Name | Revision | Lang | Subject | Date |
|---|---|---|---|---|
| SA 2008 - October | en | Control Cable Tension and Inspection of Ailerons and Rear Wing Root | 11/29/2008 | |
| SA 2009 - July | en | 'Chris Heintz' Letter of July 7, 2009 | 07/08/2009 | |
| SA 2009 - November | en | Mandatory Upgrade, Before Next Flight | 11/23/2009 | |
| SA 2009 - November | 1 | en | Mandatory Upgrade, Before Next Flight | 11/07/2009 |
| SA 2013 - September | en | Failed Rudder Pedals | 09/26/2013 | |
| SA 2016 - February | en | Upgrading Bellcrank Control System of STOL CH 750 | 02/19/2016 | |
| SA 2017 - January | en | Inspection of Horizontal Stabilizer Tail Attachment Brackets | 12/31/2016 | |
| SA 2017 - January | 2 | en | Inspection of Horizontal Stabilizer Tail Attachment Brackets | 12/31/2016 |
| SA 2021 - December | en | CH 601 and CH 650 Series Canopy Secondary Latch Installation Required | 12/06/2021 | |
| SA 2023 - August | en | Placard Upadate / Replacement | 07/31/2023 | |
| SA 2023 - December | en | Nose Gear Bearing Update | 11/30/2023 | |
| SA 2026 - June | en | C75-W-6-10 Pitot Tube | 06/01/2026 |
| Name | Revision | Lang | Subject | Date |
|---|---|---|---|---|
| SN 2020-01 | en | Wrong Installation of Emergency Parachute on Zenair Zodiac CH-601 | 02/28/2020 | |
| SN ZE-2009-04 | en | Actions and Upgrades from AMD Safety Alert of Sat. November 7, 2009 | 11/22/2009 |
| Name | Revision | Lang | Subject | Date |
|---|---|---|---|---|
| SB 00-04 | en | One-Time Visual Inspection for Purpose of Locating Cracks in Firewall (Part A), Install Repairs on Cracked Firewall Area (Part B) and Strengthen Engine Cowl Strip Retention (Part C) | 04/17/2000 | |
| SB 95-10 | en | Zinc Coated Steel Parts Corrosion | ||
| SB 97-10 | en | Carburetor/Air Intake Box Bolts | 10/15/1997 | |
| SB 2006 - March | en | CH2000 Aircraft Muffler Systems and Carbon Monoxide (CO) Detector | 02/28/2006 | |
| SB 2011 - February | en | Inspection of Nose Gear Strut Weld for Possible Cracks at Welds | 01/31/2011 | |
| SB 2018 - October | 1 | en | Elevator Piano Hinge and Stabilizer Update | 10/11/2018 |
| SB ZE-2008-1 | en | Verification and Adjustment of Control Cables for Adequate Tension | 10/28/2008 |
| Name | Revision | Lang | Subject | Date |
|---|---|---|---|---|
| SL 1999 - June | en | Fuel Sector Valve | 05/31/1999 | |
| SL 2000 - November | en | Spins | 10/31/2000 | |
| SL 2001 - June | en | Requirement to Perform an On-Going Visual Inspection for Purpose of Locating Leaks in Engine Oil Radiator System, as Outlined in Service Manual, Engine Group, Number 22 | 06/15/2001 | |
| SL 2001 - June | en | Requirement to Perform an On-Going Visual Inspection for Purpose of Locating Cracks in Engine Muffler System, as Outlined in Service Manual, Engine Group, Number 10 | 06/14/2001 | |
| SL 2002 - August | en | Nose Gear Re-Enforcement | 08/22/2002 | |
| SL 2002 - March | en | Recommended Fix for Rear Fuselage "L" Angle (Upright) and Bulkhead Buckling | 03/06/2002 | |
| SL 2002 - October | en | Up-Dating "Closed" Inside Labels of "Gull Wing Door" Handles and General Inspection of Handles/Doors Area | 10/08/2002 | |
| SL 2002 - September | en | Adding Optional Fuel Primers to Engine Cylinders | 09/20/2002 | |
| SL 2002 - September | en | Up-Dating CH2000 Muffler System | 09/25/2002 | |
| SL 2003 - February | en | Gross Weight Increase as per CH2000 FAA Approved Type Certificate Data Sheet No. TA5CH Rev. 8 | 02/01/2003 | |
| SL 2003 - January | en | Placard Up-Date | 01/06/2003 | |
| SL 2003 - May | en | Muffler Heat Shroud | 05/10/2003 | |
| SL 2003 - October | en | Flap Switch Tab | 10/15/2003 | |
| SL 2005 - February | en | Up-Dating "Closed" Inside Labels of "Gull Wing Door" Handles and General Inspection of Handles/Doors Area | 02/28/2005 | |
| SL 2005 - June | en | Adding a Placard Beside Each Wing Tank Filler Neck and for Adding a Fuel Indicator Table to Filler at Wing Fuel Tanks | 06/06/2005 | |
| SL 2005 - November | en | Upgrade of Main Gear Wheels | 11/11/2005 | |
| SL 2006 - February | 1 | en | Installing New Lightweight Landing Gear - OPTIONAL | 01/31/2006 |
| SL 2011 - June | en | Floats: Leaks Around Some Rivets | 06/14/2011 | |
| SL 2014 - July | 1 | en | Corrosion Inspection | 07/22/2014 |
| SL 2015 - August | en | Some CH Designs are being Operated with Improperly Adjusted or Installed Nose Gear Bearings and Damaged Nose Wheel Bungees | 07/31/2015 | |
| SL 2015 - June | en | Replacement of Time Limited Parts | 05/31/2015 | |
| SL 2016 - January | 1 | en | Wing Strut and General Corrosion Inspection, Lubrication and General Aircraft Maintenance | 12/31/2015 |
| SL 2016 - June | en | Assembly Details of CH2000 Firewall & Nose Gear System | 06/06/2016 | |
| SL 2017 - August | en | Rudder Inspection | 07/31/2017 | |
| SL 2018 - February | en | Fuel System | 02/05/2018 | |
| SL 2018 - January | en | Inspection of "L" Angles in Rear Fuselage | 01/10/2018 | |
| SL 2018 - May | en | Inspection of Main Gear Spring Attachment Points | 05/30/2018 | |
| SL 2020 - April | en | Advanced Preflight After Maintenance | 04/02/2020 | |
| SL 2020 - August | en | Inspection of Aileron Root Rib, Left and Right Wings | 08/11/2020 | |
| SL 2020 - February | 1 | en | Nose Gear Bungee Upgrade to Shock Suspension System | 02/18/2020 |
| SL 2020 - July | en | Control Surface Clearances | 07/28/2020 | |
| SL 2020 - November | en | Piano Hinges and Flight Controls | 11/18/2020 | |
| SL 2020 - September | en | Nose Gear Bungee Inspection and Installation | 09/01/2020 | |
| SL 2022 - October | en | Hardware Inspection | 10/03/2022 | |
| SL 2023 - February | en | Upgrade your Rudder Pedals 7C4-1J | 02/13/2023 | |
| SL 2024 - October | en | Nose Wheel Strut Inspection / Update | 10/28/2024 | |
| SL 2024 - October | en | Seat Back Tube Inspection and Reinforcement | 10/22/2024 | |
| SL ZE-2009-01 | en | Verification of Proper Installation of "Flap Stops" (P/N 6S3-1) | 06/01/2009 | |
| SL ZE-2009-02B | en | Alternative Design for a Fuselage-Mounted Aileron Stop (a.k.a. "Torque Tube Stop") | 11/28/2009 | |
| SL ZE-2009-05 | en | Aileron Bell-Crank Stiffeners for CH 601 XL/CH 650E | 11/24/2009 | |
| SL ZE-2009-06 | en | Aileron Counter-Balance Weights | 11/25/2009 | |
| SL ZE-2009-07 | en | Airframe Upgrades for ULM Versions of CH 601 XL/CH 650E | 12/04/2009 |
| Name | Revision | Lang | Subject | Date |
|---|---|---|---|---|
| SM | en | CH2000 Trainer with Lycoming 0-235-N2C | 10/31/2002 | |
| SM | 9 | en | CH2000 Trainer with Lycoming 0-235-N2C | 04/30/2011 |
| Name | Revision | Lang | Subject | Date |
|---|---|---|---|---|
| TM | 3.0 | en | Including Some of Most Common Design and Constructions Standards | 03/31/2020 |
| Name | Revision | Lang | Subject | Date |
|---|---|---|---|---|
| EBI E508943 | en | V23 Three-Point Restraint with Dual Sensor EMA Version for Installation on Zenair CH2000 | 04/07/2004 |
| Name | Revision | Lang | Subject | Date |
|---|---|---|---|---|
| Checklist | 2 | en | Pre-Flight Checklist - Zodiac CH 601 series & 650 | 01/31/2010 |
| Draw 6-ZU-1 thru 6-ZU-4 | en | Upgrade Drawings - Wing Spar & Rear Channel; Center Spar Section; Bellcrank Channel - Doublers; Control Stops - Servo L Angles | 02/12/2010 | |
| N/A | en | Owner/Operator Reporting of Maintenance, Service and Service Difficulties | 05/31/2008 | |
| N/A | en | Installation of Airbag Components | ||
| N/A | en | Composite Design Manufactured Control Panel for all UL Engines | 06/05/2023 | |
| PG 2200A | en | Photo Guide: Nose Fork Replacement - 2200A Zenair Floats | 01/14/2014 | |
| Report | en | CH650 - Aeroelastic Analysis CH650 | 07/19/2009 | |
| Report | en | CH601Xl & CH601 - Aeroeleastic Analysis for CH601XL and CH601 with a Maximum Take Off Mass of 600kg | 05/27/2009 | |
| TP E508944 | en | Multimeter Functional Test Procedure: V23 AAIR System Installed on CH2000 | 04/13/2004 |