Service Information: Airplane Factory
Alternative Names: (Sling Aircraft)
There will be over 135,000 documents in our Service Information Indexes. If the SB that you need is not yet a link (or is not listed), Contact Us. Please mention the AD No. in your message.
Most SBs are displayed in PDF format. (Use your Browser's 'Edit | Find' function to locate an SB by number.)
Table of Contents
Assembly Instructions • Construction Manuals • Information Letters • Installation Guides • Maintenance Manuals • Miscellaneous • Notifications • Pilot's Operating Handbooks • Safety Alerts • Service Bulletins
| Name | Revision | Lang | Subject | Date |
|---|---|---|---|---|
| AI DC-KAI-000-X-F | 2 | en | Sling TSi Kit Introduction | 06/30/2020 |
| AI DC-KAI-001-X-A | 4.1 | en | Sling Kit | 11/30/2019 |
| AI DC-KAI-001-X-C | 4 | en | Sing 4 | 07/31/2017 |
| AI DC-KAI-007-X-X | 4.1 | en | Electrical Kit | 05/31/2019 |
| Name | Revision | Lang | Subject | Date |
|---|---|---|---|---|
| CM DC-KAI-000-X-G | en | Sling 4 HW Assembly Kit | 01/14/2022 | |
| CM DC-KAI-000-X-G | 0.1 | en | Sling 4 HW Assembly Kit | 08/31/2022 |
| CM DC-KAI-001-X-A | 1.9 | en | Sling 2 Empennage Kit | 10/31/2020 |
| CM DC-KAI-001-X-F | 3.2 | en | Sling 4 TSi Empennage Kit | 10/31/2021 |
| CM DC-KAI-001-X-G | en | Sling 4 HW Empennage Kit | 11/30/2021 | |
| CM DC-KAI-001-X-G | 1 | en | Sling 4 HW Empennage Kit | 05/31/2022 |
| CM DC-KAI-001-X-G | 1.1 | en | Sling 4 HW Empennage Kit | 08/31/2022 |
| CM DC-KAI-001-X-G | 1.5 | en | Sling 4 HW Empennage Kit | 11/16/2023 |
| CM DC-KAI-002-X-A | 2.1 | en | Sling 2 Wing Kit | 09/30/2021 |
| CM DC-KAI-002-X-A | 2.2 | en | Sling 2 Wing Kit | 11/06/2023 |
| CM DC-KAI-002-X-A | 2.3 | en | Sling 2 Wing Kit | 08/31/2024 |
| CM DC-KAI-002-X-F | 6.2 | en | Sling 4 TSi Wing Kit | 08/31/2021 |
| CM DC-KAI-002-X-F | 6.4 | en | Sling 4 TSi Wing Kit | 06/30/2022 |
| CM DC-KAI-002-X-F | 6.6 | en | Sling 4 TSi Wing Kit | 11/29/2023 |
| CM DC-KAI-002-X-F | 6.9 | en | Sling 4 TSi Wing Kit | 08/31/2024 |
| CM DC-KAI-002-X-G | 0.1 | en | Sling 4 HW Wing Kit | 03/31/2022 |
| CM DC-KAI-002-X-G | 0.2 | en | Sling 4 HW Wing Kit | 07/31/2022 |
| CM DC-KAI-002-X-G | 0.4 | en | Sling 4 HW Wing Kit | 11/30/2022 |
| CM DC-KAI-002-X-G | 0.6 | en | Sling 4 HW Wing Kit | 11/14/2023 |
| CM DC-KAI-002-X-G | 0.9 | en | Sling 4 HW Wing Kit | 08/31/2024 |
| CM DC-KAI-003-X-A | 3.0 | en | Sling 2 Fuselage | 09/30/2021 |
| CM DC-KAI-003-X-A | 3.1 | en | Sling 2 Fuselage | 11/27/2023 |
| CM DC-KAI-003-X-F | 7.5 | en | Sling 4 TSi Fuselage | 03/31/2022 |
| CM DC-KAI-003-X-F | 7.6 | en | Sling 4 TSi Fuselage | 08/31/2022 |
| CM DC-KAI-003-X-F | 7.7 | en | Sling 4 TSi Fuselage | 08/31/2022 |
| CM DC-KAI-003-X-F | 8.1 | en | Sling 4 TSi Fuselage | 12/08/2023 |
| CM DC-KAI-003-X-G | en | Sling 4 HW Fuselage | 10/31/2021 | |
| CM DC-KAI-003-X-G | 0.3 | en | Sling 4 HW Fuselage | 03/31/2023 |
| CM DC-KAI-003-X-G | 0.6 | en | Sling 4 HW Fuselage | 12/05/2023 |
| CM DC-KAI-003-X-G | 0.7 | en | Sling 4 HW Fuselage | 01/16/2024 |
| CM DC-KAI-003-X-G | 0.9 | en | Sling 4 HW Fuselage | 05/10/2024 |
| CM DC-KAI-004-X-A | 1.5 | en | Sling 2 Undercarriage Kit | 09/30/2021 |
| CM DC-KAI-004-X-F | 1.2 | en | Sling 4 TSi Undercarragie Kit | 05/31/2021 |
| CM DC-KAI-004-X-F | 1.4 | en | Sling 4 TSi Undercarragie Kit | 11/02/2023 |
| CM DC-KAI-004-X-G | 0.1 | en | Sling 4HW Undercarraige | 08/31/2022 |
| CM DC-KAI-004-X-G | 0.2 | en | Sling 4HW Undercarraige | 09/27/2023 |
| CM DC-KAI-004-X-G | 0.3 | en | Sling 4HW Undercarraige | 01/16/2024 |
| CM DC-KAI-004-X-G | 0.5 | en | Sling 4HW Undercarraige | |
| CM DC-KAI-005-X-A | 0.5 | en | Sling 2 Canopy Kit | 09/30/2021 |
| CM DC-KAI-005-X-A | 0.6 | en | Sling 2 Canopy Kit | 03/31/2024 |
| CM DC-KAI-005-X-F | 2.1 | en | Sling 4 TSi Canopy Kit | 08/31/2021 |
| CM DC-KAI-005-X-F | 2.4 | en | Sling 4 TSi Canopy Kit | 09/30/2022 |
| CM DC-KAI-006-X-A | 1.3 | en | Sling 2 Firewall Forward | 01/31/2021 |
| CM DC-KAI-006-X-A | 1.4 | en | Sling 2 Firewall Forward | 11/27/2023 |
| CM DC-KAI-006-X-F | 3.2 | en | Sling 4 TSi Firewall Forward | 02/28/2022 |
| CM DC-KAI-006-X-F | 3.3 | en | Sling 4 TSi Firewall Forward | 04/30/2022 |
| CM DC-KAI-006-X-F | 3.5 | en | Sling 4 TSi Firewall Forward | 03/31/2023 |
| CM DC-KAI-006-X-F | 3.6 | en | Sling 4 TSi Firewall Forward | 05/31/2024 |
| CM DC-KAI-006-X-G | 0.2 | en | Sling 4HW Firewall Forward | 08/31/2022 |
| CM DC-KAI-006-X-G | 0.3 | en | Sling 4HW Firewall Forward | 04/30/2023 |
| CM DC-KAI-008-K-G | 0.1 | en | Sling 4HW Finishing Kit | 07/31/2023 |
| CM DC-KAI-008-X-A | 1.9 | en | Sling 2 Finishing Kit | 09/30/2020 |
| CM DC-KAI-008-X-F | 2.1 | en | Sling 4 TSi Finishing Kit | 09/30/2021 |
| CM DC-KAI-008-X-F | 2.2 | en | Sling 4 TSi Finishing Kit | 07/31/2022 |
| CM DC-KAI-008-X-G | 0.2 | en | Sling 4HW Finishing Kit | 08/31/2023 |
| CM Sing 4 | 0.17 | en | Sling 4 Fuselage | 11/17/2016 |
| CM Sling 4 | 0.2 | en | Sling 4 Firewall Forward | 11/08/2016 |
| CM Sling 4 | 1.4 | en | Sling 4 Canopy Kit | 11/17/2016 |
| CM Sling 4 | 1.6 | en | Sling 4 Finishing Kit | 11/18/2016 |
| CM Sling 4 | 1.8 | en | Sling 4 Undercarriage Kit | 08/29/2017 |
| CM Sling 4 | 2.0 | en | Sling 4 Empennage Kit | 11/17/2016 |
| CM Sling 4 | 2.0 | en | Sling 4 Wing Kit | 11/17/2016 |
| Name | Revision | Lang | Subject | Date |
|---|---|---|---|---|
| IL 001 | en | Defer the Execution of Service Bulletin #0009 | 11/24/2016 | |
| IL 002 | en | Low Pressure Indication on Sling Aircraft with 912ULS Engine | 11/11/2016 | |
| IL 003 | en | Prevention of Fuel Pressure Drop on 912iS Engine when Switching the Auxiliary Fuel Pump Off | 11/30/2016 | |
| IL 004 | en | Prevention of Fuel Percolation or Vapor Lock which may Result in Engine Power Loss and Potential Damage to Pistons from Lean Mixture Detonation | 12/01/2016 | |
| IL 005 | en | Garmin GPS Losing Signal | 11/11/2016 | |
| IL 009 | en | Increase Sling 4 TSi VNE to 155 KIAS | 05/20/2019 | |
| IL 010 | en | Rotax 912 ULS Airbox Seal | 09/19/2019 | |
| IL 011 | en | Inspection of Control Stick Cap | 12/11/2019 |
| Name | Revision | Lang | Subject | Date |
|---|---|---|---|---|
| IG CH-ASS-001-X-F-0-A | en | Sling TSi - Cabin Heater | 03/05/2019 |
| Name | Revision | Lang | Subject | Date |
|---|---|---|---|---|
| MM DC-MAM-001-X-C | 1.4 | en | Sling 4 | 09/28/2018 |
| MM DC-MAM-001-X-C | 1.5 | en | Sling 4 | 07/05/2021 |
| MM DC-MAM-001-X-F | 1.0 | en | Sling 4 TSi | 12/08/2020 |
| MM DC-MAM-001-X-F | 1.1 | en | Sling 4 TSi | 10/01/2021 |
| MM DC-MAM-001-X-F | 1.2 | en | Sling 4 TSi | 08/30/2023 |
| MM DC-MAM-001-X-F | 1.3 | en | Sling 4 TSi | 12/13/2023 |
| MM DC-MAM-001-X-G | 0.1 | en | Sling 4 HW | 02/10/2023 |
| MM DC-MAM-002-X-B | 2.5 | en | Sling 2 & Sling LSA | 09/28/2018 |
| MM DC-MAM-002-X-B | 2.6 | en | Sling 2 & Sling LSA | 04/29/2021 |
| MM DC-MAM-002-X-B | 2.7 | en | Sling 2 & Sling LSA | 07/07/2021 |
| MM DC-MAM-002-X-B | 2.9 | en | Sling 2 & Sling LSA | 11/26/2021 |
| Name | Revision | Lang | Subject | Date |
|---|---|---|---|---|
| Not 0001 | en | MGL OAT Probe Grounding | 11/26/2015 | |
| Not 0002 | en | Wires Overheating on Rotax 912 iS B-Side Voltage Regulators | 11/11/2016 | |
| Not 0005 | en | Loss of Mode C on the Transponder of the Garmin G3X | 11/20/2017 | |
| Not 0007 | en | Modification of Air Filter Housing | 05/07/2019 | |
| Not 0008 | en | Potential Risk of Trim Tab Disconnecting from Elevator | 06/04/2021 | |
| Not 0009 | en | Static Longitudinal Stability - Permitted Removal of Elevator Centre Balance Weights | 12/09/2021 | |
| Not 0011 | en | Throttle Cable Inspection | 10/12/2022 | |
| Not 0012 | en | Equivalent Hardware for Service Bulletin 24 and Thread Inspection | 06/14/2024 | |
| Not 0013 | en | Approval of Use of Rotax Cover Plate to Seal Hydraulic Constant Speed Govenor Drive Attachment Face on Rotax 915 iS-3-A Engines | 12/13/2024 |
| Name | Revision | Lang | Subject | Date |
|---|---|---|---|---|
| POH DC-POH-001-X-C | 1.8 | en | Sling 4 | 09/21/2018 |
| POH DC-POH-001-X-F | 2.2 | en | Sling 4 TSi | 02/01/2021 |
| POH DC-POH-001-X-F | 3.0 | en | Sling 4 TSi | 07/14/2021 |
| POH DC-POH-001-X-F | 3.1 | en | Sling 4 TSi | 11/19/2021 |
| POH DC-POH-001-X-F | 3.2 | en | Sling 4 TSi | 12/13/2023 |
| POH DC-POH-002-X-A | 2.5 | en | Sling LSA | 09/21/2018 |
| POH DC-POH-002-X-A | 3.0 | en | Sling LSA | 04/23/2021 |
| POH DC-POH-002-X-A | 3.2 | en | Sling LSA | 06/02/2022 |
| POH DC-POH-002-X-B | 2.7 | en | Sling 2 | 06/10/2019 |
| Name | Revision | Lang | Subject | Date |
|---|---|---|---|---|
| SA 0001 | en | Cancelled Mandatory Fuel Fitting on Rotax 912 iS Engines | 11/11/2016 | |
| SA 0001 | en | Mandatory Fuel Fitting on Rotax 912 iS Engines | 11/13/2012 | |
| SA 0002 | en | Mandatory Fuel Hose | 06/18/2013 | |
| SA 0003 | en | Mandatory Unable to Set Flap Position with the 4-Position Flap Controller | 11/29/2013 | |
| SA 0004 | en | Mandatory High Pressure GUD E13 Fuel Filters - Fitted between the Fuel Pumps and the Rotax 912 iS Engine - Must be Changed Every 100 Hours to Prevent Blockage and Possible Engine Stoppage | 03/13/2014 | |
| SA 0005 | en | Mandatory Fuel Pickup in the Fuel Tank. The New Style Fuel Pickup Inside the Fuel Tanks could Inadvertently be Turned while Installing Fuel Line Fittings During Assembly or Maintenance. The Pickup Could be Turned so that the Pickup is Facing Upwards which Means that Up to 12 Litres (3 US Gallons) Unusable Fuel is Left in the Tank | 03/14/2014 | |
| SA 0006 | en | Mandatory Parachute Blow-off Skin Incorrectly Installed which may Prevent the Parachute from Deploying Correctly | 05/14/2015 | |
| SA 0007 | en | Mandatory Fuel Filter Fitment | 01/04/2016 | |
| SA 0008 | en | Cancelled Risk of Failure of Propeller Hub in Ground Adjustable Warp Drive Propeller Systems Fitted to Rotax 912 iS Engines | 11/10/2016 | |
| SA 0009 | en | Cancelled Potential Risk of Failure when Attempting to Activate the Parachute Rocket | 01/26/2018 | |
| SA 0010 | en | Mandatory Potential Risk of Rudder Pedal getting Caught on a Button Head Screw of Centre Console when Rudder is Fully Deflected | 08/06/2019 | |
| SA 0011 | en | Mandatory Replacement of Fuel Pump Assembly for 915 iS and 912 iS Engines | 10/14/2019 | |
| SA 0012 | en | Mandatory Sub-Standard High Pressure Rudder Fuel Hose Rupturing Between High Pressure Pumps and Engine Fuel Rail | 07/02/2024 | |
| SA 0012 | 1 | en | Mandatory Sub-Standard High Pressure Rudder Fuel Hose Rupturing Between High Pressure Pumps and Engine Fuel Rail | 09/09/2024 |
| Name | Revision | Lang | Subject | Date |
|---|---|---|---|---|
| SB 0001 | en | Mandatory Longitudinal Cracks Appearing in the Main Landing Gear | 04/08/2014 | |
| SB 0002 | 2 | en | Mandatory Reinforcement of the Upper Join between the Centre and Rear Fuselages | 02/11/2021 |
| SB 0003 | en | Mandatory Amendment to the Sling 2 Series Annual Inspection | 11/26/2015 | |
| SB 0004 | en | Mandatory Placement of the ELT Antenna | 08/19/2015 | |
| SB 0005 | en | Mandaoty Incorrect Material Used on Guides which Could Lead to Premature Wear on Pushrods | 09/03/2015 | |
| SB 0006 | en | Mandatory MASTER Switch | 09/07/2015 | |
| SB 0007 | en | Mandatory Master Key Failure | 11/12/2015 | |
| SB 0008 | en | Mandatory Inspection of Propeller Hub - Ground Adjustable Warp Drive Propellers | 11/10/2016 | |
| SB 0009 | 1 | en | Mandatory Installation of Restricted Bypass Line between Fuel Inlet & Return Lines & Check Valve Line Around Fine Fuel Filter | 09/19/2016 |
| SB 0010 | en | Mandatory Amendment to the Sling 2 and Sling 4 Series Annual Inspection | 02/09/2017 | |
| SB 0011 | en | Mandatory Repositioning and Cooling of B Regulator on Rotax 912 iS Engines | 07/26/2017 | |
| SB 0012 | en | Mandatory Potential Risk of Failure when Attempting to Activate the Parachute Rocket Due to Incorrect Installation of Rocket Activation Cable | 02/07/2018 | |
| SB 0013 | en | Mandatory Rudder Pedal Stop Replacement | 06/08/2018 | |
| SB 0014 | en | Mandatory Rivet Replacement Along Fuselage Main Spar Carry-through and on Upper and Lower Inboard Wing Skins | 08/07/2019 | |
| SB 0014 | 1 | en | Mandatory Rivet Replacement Along Fuselage Main Spar Carry-through and on Upper and Lower Inboard Wing Skins | 09/04/2019 |
| SB 0015 | en | Mandatory Modifications to Main Axle Mounts | 08/07/2019 | |
| SB 0016 | en | Mandatory Modification of ECU Standoffs | 03/26/2020 | |
| SB 0017 | en | Mandatory Potential Risk of Shearing of Control Stop Plate Rivets | 07/01/2020 | |
| SB 0018 | en | Mandatory Insufficient Swaging of Oval Sleeves on the Rudder Cables | 07/28/2020 | |
| SB 0019 | en | Mandatory Throttle Cable Replacement to Prevent Potential Loss of Engine Power Control | 01/10/2021 | |
| SB 0020 | 1 | en | Mandatory Eyebolt Inspection and Conditional Repalcement | 07/09/2022 |
| SB 0021 | en | Mandatory Missing Elvator Torque Tube Locking Bushes | 01/25/2023 | |
| SB 0022 | en | Mandatory Replacement of Improperly De-Embrittled Bolts | 01/06/2023 | |
| SB 0023 | en | Mandatory Incorrect Nose Gear Bolt Replacement | 01/06/2023 | |
| SB 0024 | en | Mandatory Throttle Cable Replacement to Prevent Potential Loss of Engine Power | 01/06/2023 | |
| SB 0025 | en | Mandatory Foam Removal from Sling 4 TSi Parachute Box | 06/14/2024 | |
| SB 0026 | en | Mandatory Inspection and Possible Replacement Instructions of the Sling 4 TSi Seatbelt Shoulder Guide Anchor Bolts | 06/14/2024 | |
| SB 0027 | en | Mandatory Interference of TSi Firewall Cutout and Left Nose Gear Pushrod | 09/19/2024 |
| Name | Revision | Lang | Subject | Date |
|---|---|---|---|---|
| N/A | en | Sling 4 Specifications |