The Aviation DataBase: Service Information: Grumman American Aviation
The Aviation DataBase®
Complete Aviation Regulatory Library
Sept. 11 Sept. 11
DataBases updated: Jul 16th, 2025
Home Products Library Support Account Login Contact
Accessory Kits
NameRevisionLangSubjectDate
en Fire Extinguisher2/1/1970
A en Winterization1/27/1971
A en Sun Screen1/27/1971
A en Child's Seat11/26/1974
B en Heated Pitot Tube11/26/1974
B en Outside Air Temperature12/2/1974
B en Flashing Beacon12/9/1974
A en Landing Light12/13/1974
C en Gyro11/21/1973
B en Turn and Bank12/16/1974
D en Hourmeter 11/7/1974
A en Vertical Speed Indicator1/27/1970
B en Cockpit Vent12/17/1974
en Climb Propeller7/1/1963
en Radio Cooling Kit for Narco Mark III and VIII8/25/1969
en Wheel Fairing2/1/1970
B en Turn Coordinator12/17/1974
A en Climb Propeller12/18/1974
B en Shoulder Harness2/1/1974
A en Oversize Tire12/20/1974
A en Auxiliary Power Plug3/28/1974
en Stall Warning Controller9/25/1970
en Canopy Trim ('73 Canopy Interior for '72 Aircraft)1/19/1973
en AA-5 Winterization1/22/1973
en Large Wheel Fairing2/22/1973
en Hourmeter11/11/1974
en Sun Screen11/19/1974
en Landing Gear - Nose Landing Gear - Addition of Shock Absorbers7/17/1978
en Engine - Installation of Oil Cooler3/11/1977
en Installation of Large Oil Cooler on AA-5B Tiger Aircraft
en Hour Meter5/2/1991
en Installation of Auxiliary Power Plug on AG-B Tiger Aircraft
en Engine Cowl Modification / Installation of8/25/1993
en AA-1 and AA-5 Series9/30/1990
Formation Flying Manuals
NameRevisionLangSubjectDate
A2 en Section 11 - Formation Standards - Supplement to T-344/1/2006
A3 en Section 11 - Formation Standards - Supplement to T-347/1/2006
Illustrated Parts Catalogs
NameRevisionLangSubjectDate
en AA-1 Series
revised en AA-1C T-Cat & Lynx 1977/781/15/1978
en AA-5, AA-5A & AA-5B8/31/1975
3 en AA-5A Cheetah and AA-5B Tiger (1977, 1978 and 1979)6/1/1983
4 en AA-5A Cheetah and AA-5B Tiger (1977, 1978 and 1979)7/15/1992
revised en GA-7/Cougar12/10/1977
Inspection Procedures
NameRevisionLangSubjectDate
en AA-5, AA-5A & AA-5B Annual or 100-hour Inspection
en Annual or 100-Hour Inspection Procedure Guideline (Aircraft in Service Hours)9/30/1977
Maintenance Manuals
NameRevisionLangSubjectDate
en AA-1C T-Cat & Lynx (1977/78)12/15/1976
revised en AA-1C T-Cat & Lynx (1977/78)1/15/1978
5 en AA-5 Traveler, AA-5A Cheetah and AA-5B Tiger3/1/2004
revised en AG-5B9/1/2003
en G-164A, G-164B & G-164C11/30/1977
en G-164D11/30/1994
revised en GA-7/Cougar7/10/1978
Owner's Manuals
NameRevisionLangSubjectDate
en AA-1 Yankee
reissued en AA-1 Yankee1/15/1979
en AA-1A5/31/1973
en AA-1B Trainer & Tr2
reissued en AA-1B Trainer & Tr21/15/1979
en AA-5 and Traveler8/31/1974
en AA-5A and Cheetah
Pilot's Operating Handbooks
NameRevisionLangSubjectDate
reissued en AA-1 Yankee1/15/1979
en AA-1A
1 en AA-1C T-Cat and Lynx (1977)2/15/1977
en AA-5
4 en AA-5A Cheetah (1977/1978/1979)3/2/1988
4 en AA-5B Tiger (1977/1978/1979)5/12/1980
revised en GA-7/Cougar9/14/1987
Service Bulletins
NameRevisionLangSubjectDate
en Beef-Up of Aileron Cable Control Sector Support Brackets in Lower Wing Panels (A/C #1 thru #100 Only)1/24/1962
en Spray Pump Fan Armor Plates6/17/1963
en Rework of Throttle Arm on Carburetors of Continental R670 200 & 240 HP Engines Mounted on G-164 Aircraft8/29/1963
en J5404 Grumman-Sensenich Propeller Alert9/9/1965
A en J5404 Grumman-Sensenich Propeller Alert10/21/1965
en Alert Cracks in Elevator Torque Tube (Inboard End) of G-164 A/C3/8/1966
en Rework of Parking Brake Control Lock Device2/15/1967
en Substitution of AN911-3S Pipe Nipple Fitting for AN911-3D (Aluminum Alloy) Fittings in the Fuel System of G-164A Aircraft Fitted with R-1340 (600 hp) Engines10/27/1971
en Substitution of AN912-4S Reducer Fitting for AN912-4D (Aluminum Alloy) Fitting in the Fuel System of G-164A Aircraft Fitted with R-1340 (600 hp) Engines6/12/1972
en Inspection of Bolts Connecting Elevator Torque Tubes with Elevator Control Horn8/1/1973
en Parking Brake Handle5/20/1977
en Rudder Tube Corrosion6/6/1977
en Wing Fitting Corrosion10/16/1978
A en Aileron Bellcrank Inspection and Bushing Installation1/25/1980
en Grounding Strap Installation1/7/1969
en Engine Cooling Improvements5/28/1969
A en Required Inspection of the Drain Plugs in Marvel-Schebler Carburetors for Excessive Thread Lubricant11/17/1969
en Main Landing Gear Bracket Inspection12/15/1969
en Exhaust System Inspection1/9/1970
en Paint Removers5/11/1970
en Oil Pressure Line Inspection and Elbow Installation7/28/1970
en Spinner/Back Plate Inspection9/18/1970
en Throttle Control Inspection10/7/1970
A en Nose Gear Strut Inspection1/4/1971
en Carburetor Inspection2/24/1971
en Modification of 902026-1 Rear Radio Supports9/3/1971
en Weight and Balance Data Sheet Correction11/9/1971
en Control Service Bearing Support Inspection1/18/1972
A en Control Cable Inspection7/19/1974
en Fuel Tank Vent Line Inspection and Modification2/23/1972
en Front Seat Improvements3/29/1972
en Flap Motor/Right Rudder Cable Clearance Inspection3/8/1972
en Rudder System Spring Replacement5/3/1972
en Additional Aileron Drain Holes9/19/1972
en Fuel Pressure Lines Inspection10/16/1972
en Headliner Inspection and Replacement12/21/1972
en Carburetor Air Box Modification2/20/1973
en Elevator Trim Tab Hinge Inspection2/20/1973
A en Engine Mount Inspection6/22/1973
en Placard Installation6/7/1973
en Master Cylinder Inspection12/5/1973
en ELT Antenna Rivet Change12/14/1973
en Left-Hand Magneto "P" Lead Replacement1/15/1974
en Throttle Cable Housing Wear6/20/1974
en United Altimeter12/5/1974
A en Mixture Control3/12/1975
en AA-5B Upper Engine Mount Bolt Inspection1/29/1975
en Firewall Rivet Installation2/5/1975
en Rudder Control Bar Inspection2/18/1975
en Mandatory Induction Air Filter Replacement2/25/1975
en Nose Gear Strut Inspection and Protection3/3/1975
A en Carburetor Mixture Control Replacement1/12/1976
en Center Spar Console Inspection and Modification10/23/1975
A en Upper Cowl Center Hinge Replacement1/22/1976
en Spar/Skin Spacer Removal2/2/1976
en Fuel Line Inspection4/9/1976
en Bondline Protection7/30/1976
en Oil Cooler Replacement10/11/1976
en Control Wheel Shaft and Bearing Inspection11/12/1976
en Carburetor Heat Valve Inspection/Replacement2/25/1977
en Alternate Static Valve Inspection and Cleaning3/21/1977
en Narco Service Bulletin ELT-10 No. 7 ELT-10 - Inspection for Corrosion5/24/1977
en Removal of Canopy Cable System2/28/1979
en Aileron Torque Tube Inspection and Modification
en Rockwell-Collins Service Bulletin No. 5 - Audio Marker Receiver-to-Transponder Interface6/1/1979
A en Aileron Inspection or Modification11/9/1979
en Seat Belt Replacement10/1/1979
en McCauley Propeller Hub Inspection11/9/1979
A en McCauley Propeller Hub Inspection1/7/1980
B en McCauley Propeller Hub Inspection10/19/1981
C en McCauley Propeller Hub Inspection5/12/1983
en Aileron Torque Tube Joint Inspection1/29/1980
en Outboard Elevator Drain Holes3/18/1980
en Air Filter Retention Screen7/23/1981
en Voltage Regulator Replacement6/3/1981
en Seat Belt Attachment Bracket Replacement3/11/1985
en Inspection of Carburetor Heat Butterfly Valve6/26/1987
en Inspection of Carburetor Inlet Duct6/26/1987
en Mandatory Integral Fuel Tanks - Inspection For Deteriorated Access Cover Sealant and Fuel System Contamination7/26/1989
en Alternator Light Circuit Modification4/5/1991
en Inspection of Aileron Torque Tubes9/11/1991
en Inspection of Nose Landing Gear Torque Tubes7/30/1993
en Flap Torque Tube Bearing Assembly9/25/1992
en Fuel System Inspection11/28/1992
en Fuel System Contamination11/18/1992
en Artex - H4K Emergency Locator Transmitter Model 110-43/10/1993
en Parker Hannifin Wheel and Brake "Master Cylinders"6/29/1993
en Aileron Control Interference7/10/1993
en Wing Attach Shoulder Bolts10/30/1993
en Wing Attach Shoulder Bolts7/6/1994
A en Wing Attach Shoulder Bolts1/10/2005
en Interior Parts Corrosion5/10/1995
en Engine Oil Breather Blockage11/6/1997
en Ruptured Instrument Pressure Lines12/15/1999
en Missing Rivets9/16/2002
en Throttle Cables3/1/2005
en Rear Seat Belt Attach Bracket4/1/2005
en Aft Fuselage Inspection8/20/2009
en Aft Wing Spar Corrosion11/5/2010
en Control Column Bearing Lubrication8/1/2011
A en Bondline Inspection6/1/2021
Iss D en Frozen Analog Output after Processor BITE Failures4/1/2015
A en Mandatory Flight Controls Elevator Hinge and Spar, Inspection and Repair2/21/1991
Service Instructions
NameRevisionLangSubjectDate
en AD 79-22-04, Alternate Means of Compliance8/1/2006
Service Kits
NameRevisionLangSubjectDate
en S-100 - Bonding1/6/1969
A en Potting3/22/1974
en Engine Cooling System Modification5/28/1969
en Exhaust System Modification7/11/1969
en Upper Main Landing Modification2/9/1970
A en Spinner/Back Plate Modification12/7/1970
en Cabin Floor Honeycomb Repair6/7/1971
en Rudder/Elevator Tip Rib Modification7/19/1971
C en Integral Fuel Tank Sealing Kit12/8/1975
en Defroster Improvement1/25/1972
en Front Seat Improvements3/29/1972
en Front Seat Mounting Modification6/8/1972
en Flap Position Indicator Modification8/7/1972
en Large Pulley Installation - AA5 Control System12/21/1972
B en Large Pulley Installation - AA5 Control System3/5/1973
en Shock Mount Kit - Small Wheel Fairing3/14/1973
A en Carburetor Airbox Bearing Replacement Kit3/14/1974
en Carburetor Airbox Bearing Replacement Kit3/26/1974
A en Control Surface Torque Tube Repair Kit2/5/1974
B en Headliner Replacement - Two-Place Aircraft3/19/1973
A en Headliner Replacement - 1972 AA-53/1/1973
en Headliner Replacement - 1973 AA-512/20/1972
A en Installation of U-Channels on Trailing Edge of Control Surfaces
B en Flight Controls and Structures Bondline Delamination, Repair of
B en Fuel Tank Cover Sealing Kit3/25/1974
en Export Aircraft Assembly Kit3/7/1974
en Throttle Cable Clamp Modification6/13/1974
en Canopy Track Interchange1/26/1976
en Engine - Induction Air Filter Assembly - Replacement of4/19/1977
en Landing Gear - Forged NLG Fork - Installation of10/1/1976
A en Fuel - Integral Fuel Tank Repairs12/14/1983
en Propeller - Spinner, Replacement of3/2/1979
en Flight Control - Aileron Torque Tube, Modification of6/4/1979
en Fuel System - Mechanical Fuel Pump, Replacement of
en Flight Controls - Improved Flap Actuator, Installation of11/22/1978
en Lights - Flasher Unit, Beacon, Installation of2/28/1979
en Flight Controls - Aileron Outboard Support Bearing Assembly, Replacement of3/31/1980
en Flight Controls - Aileron, Modification of8/3/1979
en Throttle Cable Support Bracket Replacement
en Fuel Primer Line Replacement
en Fuel Selector Valve Replacement
en Fuel Pump and Hose Replacement
en Wing Gap Strap Modification to Allow Use of Screws Instead of Rivets8/28/1995
en Improved Throttle Cable Installation3/1/2005
en Instrument Panel Toggle Switch Replacement for all AA-1 and AA-5 Series Aircraft10/20/1995
Service Letters
NameRevisionLangSubjectDate
en Availability of Service Bulletins and Service Letters11/15/1968
A en Control System Improvements Including: 1. Bungee Mounting Plate Replacement 2. Rudder Bearing Support Bracket Assembly Replacement7/10/1969
en Exhaust System Modification7/11/1969
en Elimination of Nose Strut Spring Plunger12/15/1969
en Canopy Attach Screw Inspection3/9/1970
en Nose Wheel Spacer Replacement3/9/1970
en Wheel Fairing Installation3/8/1970
en Canopy Improvements4/30/1970
en Landing Gear Inspection4/30/1970
en Wing Tip Stiffener Inspection4/30/1970
en Vendor Service Publication9/24/1970
en Rudder Bellcrank Modification10/14/1970
en Magneto Lead Isolation10/21/1970
en Model AA-1A Service Manual Supplement3/11/1971
en Service Information Summary3/11/1971
en Muffler Inspection3/17/1971
en Item 1. Seat Track Improvement Item 2. Canopy Track Improvement Item 3. Windshield/Canopy Hardware Improvements Item 4. Exhaust Joint Sealing Item 5. Nose Gear Inspection and Precautions Item 6. Nose Gear Strut Sealing Item 7. Static System Improvement Item 8. Air Vent Improvement Item 9. Fuel Selector Valve Lubrication Item 10. Lycoming Service Instructions 1070C and 12376/4/1971
en Cabin Floor Inspection and Modification6/7/1971
en Model AA-1A Trainer Owner's Manual Correction7/9/1971
en Rudder/Elevator Rib Rivnut Inspection7/19/1971
en Defroster Outlet Design Improvement8/3/1971
en Battery Box Cover Modification8/2/1971
en Carburetor Heat/Mixture Control Fitting Replacement9/1/1971
A en Bungee Inspection10/28/1971
en Carburetor Air Valve Screw Inspection12/9/1971
en Item 1. Stall Warning Wire Relocation Item 2. Master Cylinder Operation Item 3. Windshield/Canopy Improvement Item 4. Nose Gear Fork Installation Item 5. Canopy Attachment Improvement Item 6. Prestrolite Service Bulletin No. ASM-512/10/1971
en Propeller Care and Operating Limits1/13/1972
en Rudder Rigging2/15/1972
en Item 1. Step Drain Hole Modification Item 2. Flap Position Indicator Modification Item 3. Aileron Balance Weight Arm Modification Item 4. Canopy Latch and Lock Sealing Improvements Item 5. Canopy Track Teflon Runner Roll Pins Item 6. Rear Seat Close Out Covers Item 7. Tail Tie Down Rings8/7/1972
en Item 1. AA-1 and AA-1A Owner's Manual Leaning Procedure Change Item 2. Avco Lycoming Service Bulletin No. 355 Item 3. Avco Lycoming Service Instructions No. 1070D8/28/1972
en Fuel Quantity and Fuel Quick Drain Placards12/11/1972
en Control System Improvements12/15/1972
A en Canopy Trim Retrofit1/9/1973
en 2-Place Owner's Manual Revision1/3/1974
en Bondline Inspection Procedures2/6/1974
en Item 1. Flap Switch Boot Installation Item 2. Nose Strut Length Increase Item 3. Control Surface Torque Tube Repair Item 4. Avco Lycoming Service Publications7/22/1974
en Item 1. Windshield/Canopy Attach Screw Torque Item 2. Canopy Latch Improvement Item 3. Carburetor Heat/Mixture Control Firing Improvement Item 4. Fuel Tank Vent Inspection and Modification Item 5. Inspection Cover Installation Item 6. Avco Lycoming Service Instruction No. 12665/8/1974
en Item 1. Canopy Lock Sealing Item 2. Fuel Tank Access Cover Improvement Item 3. Carburetor Airbox Bearing Replacement Item 4. Wire Bundle Protection5/9/1974
en Buss Bar/Bearing Collar Clearance5/24/1974
en Parking Brake Rigging9/24/1974
en Improved Anti-Shimmy Washer2/3/1975
en Item 1. Approved Replacement Batteries Item 2. Battery Box Cover Inspection2/10/1975
en Improved Front Seat Bottom4/1/1975
en Landing Light Replacement6/1/1975
en Vendor Service Publications6/1/1975
en Spinner Bulkhead Preload6/10/1975
en Improved Fuel Level Visibility11/17/1975
en Flap Bondline Inspection11/17/1975
en Spark Plug Lead Fouling11/17/1975
en Parking Brake Improvement11/17/1975
en Exhaust Stack/Cowl Clearance12/1/1975
en Telex Microphone Replacement5/17/1976
en Vendor Service Publications2/16/1976
en Engine Primer O.Ring Replacement2/17/1977
en Magneto Lead Isolation and Routing5/24/1977
en Canopy Lock Release Lever Placard11/18/1977
en Replacement of Induction Air Filter Assembly12/30/1977
en Improved Sunvisor Material6/21/1978
A en AA-5 Series Fuel Sump Tank Repair8/31/1978
en New Service and Accessory Kits9/27/1978
en Narco Avionics Service Bulletin ELT-10 No. 1012/18/1978
en Upholstery Replacement/Herculon Material1/26/1979
en Carburetor Mixture Control Retainer2/16/1979
en Carburetor: Improved Method of Sealing Accelerator Pump and Economizer Rods to Reduce Throttle Friction
en TCP Fuel Additive5/16/1979
en Service Kit SK-150, Autopilot Reactivation4/30/1980
en Replacement of Induction Air Filter10/9/1981
en Automotive Gasoline Use in Gulfstream Aircraft7/28/1989
en Outboard Bearing Bracket Assembly2/9/1993
en Placards9/3/1993
en Fuel Gauge Wire Routing12/30/2002
en Outboard Wing Spar Attach Bolts4/7/2003
Service Manuals
NameRevisionLangSubjectDate
en AA-1, AA-1A & AA-1B8/31/1975
Service Notes
NameRevisionLangSubjectDate
en Main Gear Spring Failures Exclusively on the 3/4" and 7/8" Thick Gear Springs9/15/1974
Standard Repair Manuals
NameRevisionLangSubjectDate
B en All Light Aircraft7/18/1978
Miscellaneous
NameRevisionLangSubjectDate
en O-Ring Chart
en Grumman Series Light Aircraft Articles2/22/2011
en Basic Loads Analysis11/1/1963