The Aviation DataBase: Service Information: Quest Aircraft
The Aviation DataBase®
Complete Aviation Regulatory Library
Sept. 11 Sept. 11
DataBases updated: Jul 29th, 2025
Home Products Library Support Account Login Contact
Field Service Instructions
NameRevisionLangSubjectDate
en Inspecting Cushion Edging Found on the Elevator Control System Anti-Rotation Guide, and Increases the Inspection Frequency
en Removing Cushion Edging, as Installed from the Factory or Reinstalled in Accordance with SB14-07, Elevator Control System - Cushion Edging Inspection, and Installing Four Wear Pads on the Pilot and Co-Pilot Link Arms of the Elevator Bearing Assemblies
en Installing Interference Fit Fasteners to Attach the Shimmy Damper Attach Bracket to the Nose Landing Gear Trunnion04/18/2017
en Mandatory Inspection of the Nose Landing Gear (NLG) Fork (P/N 100-410-7001) for Cracks01/29/2018
Information Manuals
NameRevisionLangSubjectDate
11 en Kodiak 100 Series07/20/2012
Maintenance Manuals
NameRevisionLangSubjectDate
21 en Kodiak 100 Series02/15/2017
Pilot's Operating Handbooks
NameRevisionLangSubjectDate
22 en Kodiak 100 Series04/10/2019
Service Bulletins
NameRevisionLangSubjectDate
B en Mandatory Flap System - Flap Actuation - Mandatory Inspection Procedures06/01/2010
en Mandatory Fuel System - Mandatory Fuel Drain Valve Replacement09/16/2008
1 en Mandatory Fuel System - Mandatory Fuel Drain Valve Replacement04/23/2012
Amend 1 en Mandatory Fuel System - Mandatory Fuel Drain Valve Replacement10/03/2008
en Mandatory Fuel System - Low Fuel Sensor Replacement12/15/2008
en Mandatory Electrical - Potentiometer Replacement01/26/2009
en Mandatory Fuselage - Mandatory Inspection02/17/2009
en Mandatory Landing Gear - Main Gear Cross Tubes Inspection04/07/2009
en Mandatory AMSafe Mandatory Inertia Reel Test04/02/2009
en Mandatory Fuel System - Mandatory Fuel Drain Valve Resistance Test04/14/2009
en Mandatory Garmin AHRS Vibration Test04/20/2009
Amend 1 en Mandatory Fuselage - Vertical Tail Bolt Inspection06/09/2009
en Mandatory Flight Surfaces - Adjustment06/07/2009
Amend 1 en Mandatory Fuel System - Mandatory Inspection (Wing)07/09/2009
en Mandatory Electrical System - Generator Circuit Breaker Check Procedure06/12/2009
A en Mandatory Fuel System - Doubler Ring Screw Inspection07/17/2009
1 en Mandatory Main Landing Gear - Grease Fittings Inspection and Special Precautions04/23/2012
Amend 1 en Mandatory Main Landing Gear - Grease Fittings Inspection and Special Precautions07/15/2009
B en Mandatory Flap System - Flap Drive Actuator Replacement06/01/2010
A en Mandatory Fuel System - Reserve Fuel Bladder Inspection07/21/2009
A en Mandatory Fuel System - Mandatory Chafe Protection Addition to Main Cabin Fuel Lines07/31/2009
B en Mandatory Cargo Door - Notice Regarding Cargo Door Windows07/08/2010
A en Mandatory Fuselage - Missing Fasteners10/16/2009
A en Mandatory Main Landing Gear - Brake Line Adjustment09/11/2009
B en Mandatory Pitot Static System - Mandatory Modification10/30/2009
A en Mandatory Electrical System - Main Power Feed Cable12/01/2009
3 en Mandatory Mandatory Garmin G1000 Software Upgrade to GDU Version 10.0112/04/2012
B en Mandatory Mandatory Garmin G1000 Software Upgrade to GDU Version 10.0112/10/2009
A en Mandatory Elevator Trim Control System - Mandatory Visual Inspection11/12/2009
A en Mandatory Electrical System - Main Wiring Harness11/25/2009
A en Mandatory Electrical System - Main and Essential Bus Fuse Inspection01/26/2010
1 en Mandatory Aft Fuselage Rivet Inspection and Doubler Installation06/07/2013
A en Mandatory Aft Fuselage Rivet Inspection and Doubler Installation03/08/2010
A en Mandatory Mandatory POH/AFM Supplement Addition in Accordance with Kodiak TCDS Revision 1003/03/2010
A en Mandatory Flight Controls - Mandatory Balance Weight Inspection07/22/2010
A en Mandatory Aft Fuselage - Side Frame Fastener Inspection09/17/2010
A en Mandatory Nose Wheel Steering - Mandatory Steering Bungee Inspection and Modification10/26/2010
A en Mandatory Mandatory One-Time Master Brake Cylinder Inspection and Heel Rest Modification10/18/2010
en Mandatory Fatigue - Aft Fuselage Canted Frame Shear Clip Installation12/09/2010
en Nose Cowling Inspection and Heat Blanket Installation01/31/2011
1 en Mandatory Rudder Trim Motor Servicing02/17/2011
en Mandatory Engine Inlet Shroud Modification03/16/2011
en Garmin G1000 System Software Version 552.12 Upgrade04/18/2011
1 en Garmin G1000 System Software Version 552.12 Upgrade12/11/2012
en Mandatory Engine Drain Line Modification06/08/2011
1 en Mandatory Rudder Trim Motor Inspection06/01/2011
en Mandatory Nose Gear Piston Tube Cap Replacement07/01/2011
en Mandatory Spar Pass-Thru Hole and Tailcone Modification06/24/2011
1 en Brake Master Cylinder Inspection08/01/2011
en Fuel Selector Cable Jam Nut Installation07/29/2011
en Mandatory Battery Box Rework10/20/2011
en Mandatory Fuel Quantity Calibration Procedures08/05/2011
1 en Mandatory Horizontal Attach Fitting Aft Spar Inspection09/14/2011
1 en Mandatory Windshield Bond-Line Inspection09/22/2011
1 en Mandatory Crew Seat Chain Plate Inspection10/05/2011
en Mandatory Crew Seat Stop Bracket Addition10/07/2011
en Mandatory Inertial Particle Separator Bolt Replacement11/01/2011
en Mandatory Pitch Trim Cable Inspection Procedures11/02/2011
en Crew Door Roll Pin Safety Wire Installation11/11/2011
en Mandatory Autopilot Servo Chafe Protection Installation01/31/2012
en Mandatory Cockpit Floor Access Panel Installation02/29/2012
1 en Mandatory Cockpit Floor Access Panel Installation04/24/2013
en Mandatory Floor Board Screws Replacement05/10/2012
en Mandatory Kodiak 100 Fuel Quantity Calibration05/31/2012
en Mandatory Nose Landing Gear Seal and Centering Pin Replacement06/12/2012
en Mandatory Wing Skin Fay Surface Seal Application Instructions06/20/2012
en Mandatory External Cargo Compartment Jack Point Removal09/26/2012
en Mandatory Windshield Securing System Installation11/09/2012
1 en Mandatory Windshield Securing System Installation01/23/2013
2 en Mandatory Windshield Securing System Installation05/16/2013
en Cargo Door Catch Switch Actuator Upgrade01/16/2013
1 en Elevator Down-Stop Bumper Replacement03/28/2013
en Mandatory Nose Wheel Spacer Installation11/01/2013
en Mandatory Main Landing Gear Fastner Corrosion Protection11/01/2013
en Aft Fuselage Drain Holes11/01/2013
en Mandatory Ten Thousand Hour Life Extension Field Retrofit06/08/2013
en Mandatory Software Upgrade - Oil Temperature11/11/2013
2 en Mandatory Software Upgrade - Oil Temperature05/22/2014
en Mandatory Visor Bracket11/18/2013
en Installation of Hobbs Disable Placards11/21/2013
en Mandatory Inspection and Replacement or Modification of Master Control Unit12/03/2013
en Mandatory External Cargo Compartment Drain Holes02/11/2014
en Mandatory Aileron Leading Edge Skin and Nose Rib Inspection04/28/2014
1 en Mandatory Aileron Leading Edge Skin and Nose Rib Inspection01/27/2016
1 en Mandatory TKS Console Tank Level Indicator Installation06/12/2014
en Mandatory Slinger Ring Inspection06/10/2014
en Mandatory Flap Actuator Drive Cable Nut Torque06/12/2014
en Nose Landing Gear Upgrades06/19/2014
en Mandatory Elevator Control System - Cushion Edging Inspection08/26/2014
1 en Mandatory Elevator Control System - Cushion Edging Inspection11/23/2015
en Mandatory Wingtip Navigation Light Replacement09/08/2014
en Mandatory Elevator Doubler Installation10/30/2014
1 en Mandatory Elevator Doubler Installation12/11/2014
en Mandatory Rudder Cable Pass-Through Doubler Installation10/31/2014
1 en Porous Panels Flow - Cav Ice Protection System04/13/2016
en Yoke Anti-Rotation Guide Wear Pad Upgrade03/26/2015
en Mandatory Rudder Pulley Bracket Inspection06/09/2015
1 en Mandatory Main Landing Gear Tire Tubes12/28/2015
en Mandatory Inspect Visor Bracket Mount Joint01/12/2016
en Mandatory Floor Frame, Crack Repair FS17906/24/2016
1 en Mandatory Floor Frame, Crack Repair FS17911/10/2016
Service Letters
NameRevisionLangSubjectDate
en Main Landing Gear - Recommended Tire Inspection07/10/2008
en Door Assembly - New Latch Handle Assembly07/18/2008
1 en Door Assembly - New Latch Handle Assembly04/23/2012
en KODIAK 100 Series Pilot Operating Handbook- Revision 108/15/2008
en Cockpit - One-Time Pilots Side Control Pedestal Bolt Inspection10/10/2008
Amend 1 en Temporary Loss of Attitude and Heading on Both Primary Flight Displays (PFDs)02/09/2009
en Flight Controls - 22 Degree Elevator Change04/21/2009
en Exhaust Stack Installation and Removal Instructions05/06/2009
en Instructions for Aircraft Field Modification of Cabin Light Time Delay Relay05/22/2009
en Parachute Operations - Installation Kit06/11/2009
en Control Column - Re-Index Sequence05/07/2009
A en Cargo Door - Window Replacement07/02/2009
A en Improvement for Aircraft - Seat Track Station Identification Markings07/31/2009
A en KODIAK Specific Repair Instructions - Indention on Horizontal Stabilizer10/27/2009
A en Cargo Door - Window Replacement07/08/2010
Service Notices
NameRevisionLangSubjectDate
en Garmin LPV and LNAV/VNAV Approaches with Three Character Airport Identifiers07/29/2008
en Cold Climate Conditions may cause SVT Pathways to Intercept the Glidepath at a Higher Altitude than the Published Altitude01/21/2009
en Garmin G1000 System SD Card Incompatibility04/07/2009
en Fuel System Poppet Valve Notice04/07/2009
en Fuel Bladder Assembly Ring04/12/2009
en Operations in Australia, New Zealand and South Pacific Regions05/29/2009
en Possible Temporary Loss of Heading/Attitude Information in Garmin Integrated Flight Deck and G600 Systems Following Extended Power-on Stall Maneuvers05/01/2009
1 en Possible Temporary Loss of Heading/Attitude Information in Garmin Integrated Flight Deck and G600 Systems Following Extended Power-on Stall Maneuvers04/23/2012
en Momentary Failure Indications (Red-X) can Occur when Deleting Stored Data07/14/2009
en Fuel System - Special Notice Regarding Maintenance on Reserve Fuel Bladder07/14/2009
en Garmin G1000 - 0933 Revision A07/31/2009
1 en Garmin G1000 - 0933 Revision A04/23/2012
A en Special Air Worthiness Information Bulletin from the FAA09/04/2009
A en POH/AFM - Initial Release of 100-000-904 IR09/03/2009
A en POH-AFM - Placard Adjustments09/11/2009
A en Special Airworthiness Information Bulletin Pratt and Whitney Canada10/15/2009
A en Foreign Certification - KODIAK Requirements for Registration in Canada10/01/2009
A en POH-AFM - Revisions 1, 2 and 3 Update Package10/20/2009
A en Garmin G1000 - Service Advisory 0944 Revision A10/15/2009
A en Information Notice, Control Yoke Interconnect Turnbuckle Thread Engagement11/09/2009
A en Kodiak Aircraft Maintenance Manual, Revision 04 Released11/11/2009
A en POH-AFM - Temporary Revision AFM-TR-04-0112/04/2009
A en Garmin Service Bulletin 0823, Revision C12/07/2009
A en Garmin Service Alert 0824, Revision C12/07/2009
A en POH-AFM - Temporary Revision AFM-TR-04-0201/29/2010
A en Technical Publications DVD - Revision 01 to TP-2010-Q101/28/2010
1 en Kodiak 100 Certified for Increase Gross Takeoff Weight (7255 Lb) and Ramp Weight (7305 Lb)04/23/2012
A en Kodiak 100 Certified for Increase Gross Takeoff Weight (7255 Lb) and Ramp Weight (7305 Lb)03/03/2010
A en G1000 - Garmin Service Alert 1001, Revision A02/08/2010
A en Kodiak POH/AFM 100-000-901 Obsoleted03/03/2010
A en Kodiak POH/AFM Revision 05 Release and Aircraft Maintenance Manual Revision 05 Release03/03/2010
A en POH-AFM - Temporary Revision AFM-TR-05-0103/08/2010
A en AMM - Temporary Revision AMM-TR-05-0103/08/2010
A en Temporary Revision - AFM-TR-05-02 and AMM-TR-05-0205/05/2010
A en Temporary Revision - AMM-TR-05-0605/27/2010
A en Temporary Revision - AMM-TR-06-0110/04/2010
A en Aircraft Maintenance Manual Revision 06 Release08/04/2010
A en Pilot's Operating Handbook and Airplane Flight Manual (POH/AFM) Revision 06 Release10/01/2010
A en POH-AFM Supplement 05 Gross Weight Increase 7,255 Revision 01 Release10/01/2010
A en Temporary Revision - AMM-TR-06-0210/04/2010
A en Temporary Revision - AMM-TR-06-0310/04/2010
A en Temporary Revision - AFM-TR-06-0110/04/2010
A en Release of Wiring Diagram Manual 100-WDM-00210/11/2010
A en Notice Regarding Cargo Restraints and Tie-Down Fittings Used on the Kodiak 10010/14/2010
en Kodiak 100 Certified for Flight into Known Icing (FIKI)11/11/2010
en POH/AFM - Revision 0711/23/2010
1 en Aircraft Maintenance Manual Revision 07 Release01/10/2011
en Service Notification Program Outline03/16/2011
1 en Temporary Revision - AMM-TR-07-0103/02/2011
en AMM Temporary Revision TR-07-02, TR-07-03, and TR-07-0402/16/2011
en Surface Effects Shimmy Damper Release03/09/2011
en KODIAK 100 Series POH/AFM Revision 08 Release03/24/2011
en KODIAK 100 Maintenance Manual Revision 08 Release03/28/2011
en AMM Temporary Revision TR-08-0104/27/2011
en Nose Gear Hyperextension04/16/2012
en Garmin Electronic Checklist Update10/16/2012
en External Cargo Compartment Serialization Placard01/15/2013
en Crew Door Bumpers02/11/2013
en Garmin G1000; Service Advisory 1309 Rev. B03/06/2013
1 en Garmin G1000; Service Advisory 1309 Rev. B04/04/2013
en KODIAK 100 Battery Care05/16/2013
en Garmin FliteCharts Data Alert 132705/09/2013
en Available KODIAK® 100 Factory Upgrades/Improvements07/22/2013
1 en Available KODIAK® 100 Factory Upgrades/Improvements02/18/2014
2 en Available KODIAK® 100 Factory Upgrades/Improvements05/22/2014
3 en Available KODIAK® 100 Factory Upgrades/Improvements12/02/2015
en Garmin G1000 Service Advisory 1344 Revision B08/06/2013
B en Garmin G1000 Service Advisory 1344 Revision B12/09/2013
en Garmin G1000 Service Advisory 1348 Revision A08/15/2013
en Garmin Terrain Data Alert 135109/05/2013
en Garmin G1000 Installation Bulletin: IB134109/28/2013
en Garmin G1000 Service Advisory 1352 Revision A09/30/2013
en ELT Metal Strap10/17/2013
en Garmin G1000 Service Bulletin 135310/21/2013
en Garmin G1000 Service Advisory 1363 Revision A11/26/2013
en Garmin G1000 Service Advisory 1372 Revision A12/17/2013
en Rigging Instruction Update04/03/2014
en KODIAK® 100 Airplane Maintenance Manual Format Changes07/01/2014
en KODIAK 100 G1000 Software Configurations and Updates09/08/2015
1 en KODIAK 100 G1000 Software Configurations and Updates10/02/2015
3 en KODIAK 100 G1000 Software Configurations and Updates06/14/2016
5 en KODIAK 100 G1000 Software Configurations and Updates07/19/2016
6 en KODIAK 100 G1000 Software Configurations and Updates10/19/2016
7 en KODIAK 100 G1000 Software Configurations and Updates01/11/2017
en Inspection and Replacement of Halon Blend Crew Door Fire Extinguishers11/04/2015
en Corrosion Prevention and Control Program for the KODIAK® 10008/09/2016
en Parker Hannifin Corporation 40-177A Wheel Assembly Service Bulletin SB711602/13/2017
Miscellaneous
NameRevisionLangSubjectDate
en Kodiak Specifications and Options07/01/2012
en Kodiak Warranty Claim Form05/01/2010
en Kodiak Publication Status10/01/2013
2 en Kodiak Warranty Information10/01/2010